Acessibilidade / Reportar erro

Enzymatic resolution of (R,S)-ibuprofen and (R,S)-ketoprofen by microbial lipases from native and commercial sources

Resolução enzimática do (R,S)-ibuprofeno e (R,S)-cetoprofeno por lipases microbianas de fontes nativas e comerciais

Abstracts

The enantioselectivity (E) of native lipases from Aspergillus niger, Aspergillus terreus, Fusarium oxysporum, Mucor javanicus, Penicillium solitum and Rhizopus javanicus in the resolution of (R,S)-ibuprofen and (R,S)-ketoprofenenantiomers by esterification reaction with 1-propanol in isooctane was compared with known commercial Candida rugosa (Sigma) and Candida antarctica (Novozym®435) lipases. In the resolution of (R,S)-ibuprofen, C. rugosa lipase showed good selectivity (E = 12) while Novozym®435 (E = 6.7) and A. niger (E = 4.8) lipases had intermediate selectivities. Other enzymes were much less selective (E around 2.3 and 1.5), under tested conditions. After preliminary optimization of reaction conditions (water content, enzyme concentration and presence of additives) the enantioselectivity of native A. niger lipase could be enhanced substantially (E = 15). All tested lipases showed low selectivity in the resolution of (R,S)-ketoprofen because poor ester yields and low enantiomeric excess of the acid remaining were achieved.

lipase; (R,S)-ibuprofen; (R,S)-ketoprofen; enantioselectivity


A enantioseletividade (E) das lipases nativas de Aspergillus niger, Aspergillus terreus, Fusarium oxysporum, Mucor javanicus, Penicillium solitum e Rhizopus javanicus na resolução dos enantiômeros do (R,S)-ibuprofeno e (R,S)-cetoprofeno na reação de esterificação com 1-propanol em isoctano foi comparada com as lipases comerciais de Candida rugosa (Sigma) e Candida antarctica (Novozym®435). A lipase de C. rugosa mostrou boa enantioseletividade (E = 12) comparada com as da Novozym®435 (E = 6.7), de A. niger (E=4.8) e com as outras lipases que foram muito menos seletivas (E por volta de 2.3 e 1.5) na resolução do (R,S)-ibuprofeno, dentro das condições testadas. Após uma otimização preliminar das condições da reação (conteúdo de água, concentração da enzima e presença de aditivos) a enantioseletividade da lipase de A. niger pôde ser substancialmente aumentada (E = 15). Todas as lipases testadas mostraram baixa seletividade na resolução de (R,S)-cetoprofeno, resultando baixos rendimentos de éster e de excesso enantiomérico do ácido não esterificado.

lipase; (R,S)-ibuprofeno; (R,S)-cetoprofeno; enantioseletividade


INDUSTRIAL MICROBIOLOGY

Enzymatic resolution of (R,S)-ibuprofen and (R,S)-ketoprofen by microbial lipases from native and commercial sources

Resolução enzimática do (R,S)-ibuprofeno e (R,S)-cetoprofeno por lipases microbianas de fontes nativas e comerciais

Patrícia de Oliveira CarvalhoI,* * Corresponding author. Mailing address: Rua Santo Monte, 65, Jardim Salessi.13251-131, Itatiba, SP, Brasil.Tel.: (+5511) 4034-8298, Fax: (+5511) 4034-1825 E-mail: patcarvalho@saofrancisco.edu.br ; Fabiano Jares ContesiniI; Masaharu IkegakiII

IUniversidade São Francisco, Bragança Paulista, SP, Brasil

IIDepartamento de Farmácia, Universidade Federal de Alfenas, Alfenas, MG, Brasil

ABSTRACT

The enantioselectivity (E) of native lipases from Aspergillus niger, Aspergillus terreus, Fusarium oxysporum, Mucor javanicus, Penicillium solitum and Rhizopus javanicus in the resolution of (R,S)-ibuprofen and (R,S)-ketoprofenenantiomers by esterification reaction with 1-propanol in isooctane was compared with known commercial Candida rugosa (Sigma) and Candida antarctica (NovozymÒ435) lipases. In the resolution of (R,S)-ibuprofen, C. rugosa lipase showed good selectivity (E = 12) while NovozymÒ435 (E = 6.7) and A. niger (E = 4.8) lipases had intermediate selectivities. Other enzymes were much less selective (E around 2.3 and 1.5), under tested conditions. After preliminary optimization of reaction conditions (water content, enzyme concentration and presence of additives) the enantioselectivity of native A. niger lipase could be enhanced substantially (E = 15). All tested lipases showed low selectivity in the resolution of (R,S)-ketoprofen because poor ester yields and low enantiomeric excess of the acid remaining were achieved.

Key words: lipase, (R,S)-ibuprofen, (R,S)-ketoprofen, enantioselectivity

RESUMO

A enantioseletividade (E) das lipases nativas de Aspergillus niger, Aspergillus terreus, Fusarium oxysporum, Mucor javanicus, Penicillium solitum e Rhizopus javanicus na resolução dos enantiômeros do (R,S)-ibuprofeno e (R,S)-cetoprofeno na reação de esterificação com 1-propanol em isoctano foi comparada com as lipases comerciais de Candida rugosa (Sigma) e Candida antarctica (NovozymÒ435). A lipase de C. rugosa mostrou boa enantioseletividade (E = 12) comparada com as da NovozymÒ435 (E = 6.7), de A. niger (E=4.8) e com as outras lipases que foram muito menos seletivas (E por volta de 2.3 e 1.5) na resolução do (R,S)-ibuprofeno, dentro das condições testadas. Após uma otimização preliminar das condições da reação (conteúdo de água, concentração da enzima e presença de aditivos) a enantioseletividade da lipase de A. niger pôde ser substancialmente aumentada (E = 15). Todas as lipases testadas mostraram baixa seletividade na resolução de (R,S)-cetoprofeno, resultando baixos rendimentos de éster e de excesso enantiomérico do ácido não esterificado.

Palavras-chave: lipase, (R,S)-ibuprofeno, (R,S)-cetoprofeno, enantioseletividade

INTRODUCTION

The use and preparation of chiral pharmaceutical principles as single enantiomers is one of the most relevant goals in pharmaceutical science. For chiral drugs, opposite enantioforms act with different biological properties and the distomer could give undesirable effects. Ibuprofen and ketoprofen are important members of the class non-steroidal anti-inflammatory drugs (NSAIDs), employed as racemate in pharmaceutical formulations, but have their pharmacological activity mainly in belonging in S(+)-enantiomer (25).

Lipases (EC 3.1.1.3) are very suitable enzymes for organic syntheses because they accept a wide range of non-natural substrates, are stable and active in organic solvents, do not require cofactors, and are readily available from several (micro) organisms. In organic solvents, lipases can be more enantioselective and the solubility of hydrophobic substrate can be enhanced (11,15). Possible approaches to the enzymatic resolution of chiral profens include the enantioselective hydrolysis (28,41,46), transesterification (19,38) or the direct esterification in non-aqueous medium using microbial lipase (13,32,39). There are a certain number of lipases produced by yeast, most of them belonging to the Candida genus, which have been used for biotechnological purposes. Lipases from Candida rugosa (cylindracea), Candida antarctica and Rhizomucor miehei have been used to resolve the enantiomers of ibuprofen (29,32,44), naproxen (35,39,43), suprofen (40) and flurbiprofen (5). Some studies have been done exploiting the enantioselectivity from novel microbial lipases (6,7,27). In a preliminary study, we reported that some native lipases provided good results in terms of thermostability and enantioselectivity in the esterification reaction using racemic substrates (8,9).

The objective of this work was to characterize the catalytic performance of six crude native lipase preparations in terms of the enantioselective resolution of (R,S)-ibuprofen and (R,S)-ketoprofen using 1-propanol as acyl acceptor. We have used lipase-producing microorganisms isolated from natural sources and compared their lipases with commercial lipases from hydrolysis (28,41,46), transesterification (19,38) or the direct esterification in non-aqueous medium using microbial lipase (13,32,39). There are a certain number of lipases produced by yeast, most of them belonging to the Candida genus, which have been used for biotechnological purposes. Lipases from Candida rugosa (cylindracea), Candida antarctica and Rhizomucor miehei have been used to resolve the enantiomers of ibuprofen (29,32,44), naproxen (35,39,43), suprofen (40) and flurbiprofen (5). Some studies have been done exploiting the enantioselectivity from novel microbial lipases (6,7,27). In a preliminary study, we reported that some native lipases provided good results in terms of thermostability and enantioselectivity in the esterification reaction using racemic substrates (8,9).

The objective of this work was to characterize the catalytic performance of six crude native lipase preparations in terms of the enantioselective resolution of (R,S)-ibuprofen and (R,S)-ketoprofen using 1-propanol as acyl acceptor. We have used lipase-producing microorganisms isolated from natural sources and compared their lipases with commercial lipases from Candida rugosa (Sigma) and Candida antarctica (NovozymÒ435). In addition, a preliminary optimization with respect to the influence of the water content, enzyme concentration and the presence of additives in the yield ester (conversion degree) and the enantioselectivity value (E-value) of selected lipases were carried out.

MATERIALS AND METHODS

Chemicals

Crude commercial Candida rugosa lipase was obtained from Sigma Chemical Co (St Louis, MO, USA) and NovozymÒ435 (lipase immobilized on acrylate resin from Candida antarctica) was a gift of Novozymes Latin America Ltda (Araucária, PR, Brasil). Isooctane, 1-propanol, (R,S)-ibuprofen were purchased from Sigma-Aldrich Chemical Co. (St. Louis, MO, USA) and (R,S)-ketoprofen and pures enantiomers were gifts from The Boots Company (Nottingham, UK) and Aldrich (Milwaukee, WI USA). Yeast extract and Bacto peptone were purchased from Difco Laboratories, (Detroit, MI, USA). The culture media, salts, chemical reagents and the other solvents were obtained from Merck (Darmstadt, Germany) and from Sigma-Aldrich Chemical Co. in the highest purity available. Low acidity olive oil (Carbonel) was purchased at a local market.

Microorganisms

All the microorganismsused in this study were isolated from soil and fruit samples and collected around Southest Brazil. The isolation process was performed by serial dilution of the samples according to standard techniques (33) and the taxonomic identification was performed by the Centro de Micologia da Universidade de Lisboa, Portugal.

Lipase production

Fungal lipase was produced in a medium with an initial pH value of 6.0 consisted of 2% peptone, 0.5% yeast extract, 0.1% NaNO3, 0.1%, KH2PO4 0.05% MgSO4. 7H2O and 2% of olive oil. Cultures were carried out in Erlenmeyer flasks (500 mL) containing 120 mL of the growth medium. The cultures were inoculated with 1 mL of spore suspension (105-106 spores/mL) and the flasks were shaken at 130 rpm for 72h at 35ºC on a rotary shaker. After this period, the cultures were filtered and clear filtrates were treated with ammonium sulphate (80% saturation). The precipitates were dialyzed overnight against in sodium phosphate buffer, pH 7.0, and lyophilized for use as crude lipase preparation in powder form.

Enzymatic assays

The hydrolytic activity of the solid biocatalysts was determined at 35ºC, pH 6.0 - 7.0 by the titration of free fatty acids with 0.1 N NaOH released from olive oil hydrolysis (42). The enzymatic activity was expressed as mmoles of oleic acid released per minute of reaction (mmol min-1). The amount of protein was determined by the Lowry methodology (31) using egg albumin as standard and measures the absorbance of 280nm.

Esterification reaction

The powder lipases obtained by controlled fermentation and the commercial lipases were tested in the esterification of chiral substrates using 1-propanol as acyl acceptor. The standard reaction mixture was composed of (R,S)-ibuprofen (66 mM) or (R,S)-ketoprofen, 1-propanol (66 mM) and anhydrous isooctane (10 mL) without addition of water. The reaction was started by adding 5.0 mg of lipases and carried out in sealed Erlenmeyer's on a shaker with orbital magnetic stirring at 180 rpm, at 35ºC. Samples of 100 mL of the solution were withdrawn at different times and diluted in 1.4 mL of isooctane. The amount of ester (conversion degree) formed during the reaction and the enantiomeric excess of the (S)-enantiomer were determined by gas chromatography (GC) and by high performance liquid chromatography (HPLC), respectively, as described below.

Chromatographic analysis

Gas chromatography was performed using a CHROMPACK CP 9001 gas chromatographer equipped with flame ionization detector (FID) and a CP-Sil 5 CB column (10 m x 0.25 mm x 0.12 µm). Injector temperature was 300ºC and the detector was 350ºC; oven temperature was maintained at 180ºC. Carrier gas was hydrogen with a flow of 12 mL/min. An external standard method was employed to quantify the formed ester and the remaining acid. The enantiomers of the unreacted substrate were separated by HPLC using a chiral column (Chiralcel OD, Daicel Chemical Industries, Ltd., Japan). The mobile phase was a mixture of n-hexane/Isopropanol/trifluoracetic acid (100/1/0.1 v/v/v) at a flow rate of 1.0 mL/min and detection was by UV at 254 nm.

Enantioselectivity-value (E-value) measurements

The value of enantioselectivity (E-value) was calculated from the enantiomeric excess of the substrate (ees) and the conversion degree (c) according to the method described by Chen et al. (12) (Equation 1). Free shareware programs for the calculation of the enantiomeric ratio can also be obtained via the Internet (http://www-orgc.tu-graz.ac.at).

Statistical analysis

Oneway analysis of variance (ANOVA) and Tukey´s studentized range test were used to determine differences in mean values based on data collected from three replications of each measurement. Significance was established at p < 0.05.

RESULTS AND DISCUSSION

Hydrolytic and esterication activities of lipases

The hydrolytic activity of olive oil hydrolysis in aqueous medium and the esterification activity from the reaction between (R,S)-ibuprofen with 1-propanol in isooctane of the tested lipases are shown in Table 1.

There are no significant differences between the values observed for the hydrolitic activity and specific hydrolitic activity of the native lipases. The protein percentage in the solid lyophilized biocatalysts is slightly greater in Aspergillus terreus and Novozym 453. Evidently many other proteins are also present, not only lipases, as all the preparations employed were crude enzymes. Only NovozymÒ 435 lipase is immobilized on acrylate resin (according to the manufacturer's information).

Of the native lipases tested, Aspergillus niger and Aspergilus terreus lipases resulted in the highest esterification activity in the synthesis the propilic ester of ibuprofen (20.3 and 15.1%, respectively. Fusarium oxysporum (4.9%) and Mucor javanicus (3.2%) lipases showed lower esterification activity compared with the Aspergillus species. These results did not correlate with the result obtained for the hydrolysis of olive oil where low catalytic activity was observed for Aspergillus terreus. Finally, as could be expected, the commercial Candida rugosa lipase showed the highest hydrolytic activity and NovozymÒ 435lipase the highest esterification activity.

Lipase-catalyzed enantioselective esterification

The native and commercial lipases were tested for their ability to catalyze the enantioselective esterification between racemic ibuprofen and ketoprofen with 1-propanol in isooctane. In Table 2 the summary of the final results obtained during the first 212 hours of reaction are presented.

The native crude lipase from A. niger is significantly more enantioselective for (R,S)-ibuprofen than other lipases from A. terreus, Fusarium oxysporum and Mucor javanicus. Penicillium solitum and Rhizopus javanicus lipases had no selectivity for these enantiomers. Under test conditions, the lipase from A. niger has an E-value for ibuprofen of 4.8; when the conversion reaches 25%, the enantiomeric excess of (S)-ibuprofen has the maximal value of 19.9% after 162 hours. The values are considerably higher than those previously found for the Aspergillus niger lipase (3,13). Mustranta et al. (32) reported that Aspergillus niger lipase (Biocatalyst, UK) was almost inactive in the ester formation in the resolution of racemic ibuprofen. In a previous paper we reported that lipases from A. niger and A.terreus were good candidates for biocatalysts in organic media. These lipases were highly thermostable, retaining 60% and 50% activity at 60ºC after 1 hour, respectively; and provided the best results in terms of E-value in the esterification of (R,S)-2-octanol with octanoic acid in n-hexane (E = 4.9 and E= 4.5, respectively) (9). As a rule thumb, Enantiomeric Ratios below 15 are unacceptable for practical purposes. They can be considered as moderate to good from 15-30, and above this value they are excellent (17).

It is worthwhile to note that initial esterification rate (conversion degree) for ibuprofen was higher than for ketoprofen for all lipase preparations tested. The E-value of lipases from C. rugosa and NovozymÒ 435in the resolution of ibuprofen was 2.0-fold higher than those for resolution of ketoprofen. These results have been previously observed and may be due to differences in size and geometry of the substrates. Ketoprofen is referred to as a bad substrate when lipase from C. rugosa is used as biocatalyst because poor ester yields and enantiomeric excess were achieved (20,21). Modeling using Candida rugosa lipase explained why the rule often fails when the large and branched substituent is used. The large substituent cannot fit the enzyme tunnel, and instead lies outside the tunnel in the large hydrophobic pocket, hindering the enzymatic catalysis (4).

Only the lipase from C. rugosa produced desirable conversion (approximate 50%) with E-value 12. The S-acid was converted to its ester form, leaving the (R)-ibuprofen (ee = 78%) after 54 h of reaction time. C. rugosa lipase has been widely used in the resolution of racemic acids due to its high enantioselectivity (23,30). Some authors have reported the resolution of ibuprofen using different strategies (such as alcohols and acid concentration, water content, hydrophobicity of solvents and chemically modified lipases) with higher E-value (above 50) with Candida rugosa lipase (Sigma) both without immobilization (22,45) or immobilized (2,30).

On the other hand, NovozymÒ435 displayed poor enantioselectivity, since it catalyzed the esterification of both R- and S-enantiomers (c = 64% for (R,S)-ibuprofen and 62% for (R,S)-ketoprofen) of these racemic acids. Arroyo and Sinisterra (3) reported that the E-value for the esterification of ibuprofen catalyzed by NovozymÒ435 in isooctane was 1.2 ~ 1.3.

Most of the tested lipases preferentially esterified the (S)-enantiomer; however only NovozymÒ435,A. niger and A. terreus lipases were enantioselective in relation to the (R)-enantiomer of ibuprofen and ketoprofen. This stereopreference is advantageous as it allows the direct production of the desired active S(+)-enantiomer as unreacted substrate from the enzymatic reaction without further chemical manipulation.

Conversion degree (ester yield) in the resolution of (R,S)-ibuprofen with 1-propanol catalyzed by lipases without addition of water is presented in Fig. 1.


A high degree of conversion was obtained with NovozymÒ435(64%) and C. rugosa (53%) after 54 h of reaction, in accordance with reports by other authors (2,16). Native lipases from A. niger and A. terreus showed a moderate ester yield after 162 hours of reaction (25% and 22% respectively). We observed that the reversible nature of the esterification reaction caused a worsening of the rate of propilic ester of ibuprofen with increased incubation time, due to the gradual formation of water in the reaction which hydrolyses the product. It is important to point out that crude extracts of lipase from the microorganisms, may be highly heterogeneous, showing different enzymatic activity and selectivity depending on the different operational fermentation conditions (37).

Optimal water content (% p/v)

The amount of water is one of the most influential factors on the activity of lipases in organic media (24,30). Thus, the same set of experiments was preliminarily carried out with the addition of 0.1% v/v ofwater (10 mL water in 10 mL solvent) to the reaction medium (Fig. 2). This strategy was based on previously published results stating that the addition of small amounts of water resulted in an increase in the E-value of lipases (10,36).


The influence of added water (0.1% v/v) on the synthesis of propilic ester of ibuprofen was not relevant with immobilized lipase from NovozymÒ435 and with native crude lipases under the conditions tested, whereas it greatly influenced the commercial enzyme from Candida rugosa. As can be seen, the conversion degree using lipase from C. rugosa increased at first, but later decreased with increasing time reaction, reaching its maximum rate (c = 49.2%) after 24 h of reaction. When the enzyme was used without the addition of any water (the commercial lipase powder had an adsorbed water content of 0.74% w/w determined by mass balance at 105ºC) the reaction rate was low and the ester yield was about half (c = 26.8%) of the theoretically expected value (50%) after 24 h. It is interesting to note how an excess of water in the microenvironment of the enzyme increase the hydrolase activity after 24 hours of reaction. Lipases from A. niger, A. terreus, F. oxysporum, M. javanicus and R.javanicus did not show appreciable differences in terms of conversion degree (as shown in Fig. 2) and the E-value (data not shown) compared with the reaction in the absence of water (Fig. 1). A possible explanation of this phenomenon could be that most of the water involved in the reaction mixture came from the lipase powder and it was enough for the activity of these enzymes. Although there was a great percentage of water eliminated in the lyophilization (approximately 96 - 98% for 24 h of lyophilization), an important amount of water remained in these crude lipase preparations.

In the next experiment (Table 3), the E-value of the two selected lipases, one native (A. niger) and other commercial (C. rugosa) were evaluated when different contents of water were added to the reaction mixture (0.1 - 0.4% v/v) for the resolution of (R,S)-ibuprofen.

By using C. rugosa lipase, the presence of a small water amount (0.1 - 0.2% v/v) in the reaction system increased significantly the E-value (14 and 10) for the resolution of this drug, giving the active (S)-ibuprofen (ee = 72 and 65%) with high optical purity after 24 h of reaction. Low hydration of the enzyme is believed to decrease the flexibility of enzymes, impeding their catalytic activity, because of interactions between polar residues, no longer screened by bound water molecules (1, 47). Xie et al. (45) observed that a higher racemate conversion (41.9%) and the E-value (112) were obtained when 0.1% (v/v) of water was added at a reaction time of 50 h using 60 mg of lipase from Candida rugosa (Sigma) in the esterification of (R,S)-ibuprofen with n-butanol in isooctane. However, crude commercial extracts of Candida rugosa lipase may be highly heterogeneous, showing different enzymatic activity and selectivity depending on the commercial lot (14). On the other hand, the amount of water added in the reaction mixture was not enough to modify significantly the E-value of A. niger lipase. These results confirm the previous results, indicating that this reaction mixture already has enough water for the catalysis or might even be in excess, which would justify the low E-values obtained for this lipase. In fact, the addition of 0.4% v/v of water caused a small decrease in the E-value of A. niger lipase (E = 3.2). In a reaction system, the amount of water present will depend mainly on the nature of the biocatalyst, the nature of the treatment employed for semi-purification (solvent or ammonium sulphate), the nature of the solvent used in the reaction mixture (because of their different affinity for the water) and others. To control water activity in organic media, several methods have been reported and most of them are based on the use of saturated salt solutions, which give a defined water activity (16,18).

Effect of enzyme loading

The influence of the amount of C. rugosa and A. niger and lipases in the resolution of (R,S)-ibuprofen is shown in Figs. 3 and 4, respectively. The amounts used were 5, 15, 30 and 50 mg and the reactions were examined without addition of water after 24 hours.



For commercial lipase from Candida rugosa, using 15 mg, the conversions were 42%, ee 58%, getting an E-value 16. Using 30 mg and 50 mg a slight increase of the conversions and ee values was obtained, these being 65% and 72%, with E values of 17 and 14, respectively.

On the other hand, increasing the quantity of Aspergillus niger lipase in the reaction medium improved significantly the enzyme performance with respect to esterification activity (conversion degree) and enantioselectivity. The optimal amount of enzyme was 30 mg, forming the propilic ester ibuprofen in 30% conversion, ee 26, getting an E-value of 5.1. There was not much difference in the final conversions and ee between amount of 30 mg and 50 mg of the enzyme.

This can be explained by the fact that the excess use of enzyme not only prevents the active sites of the enzyme molecules from exposing to the substrate but also leads to internal diffusion limitations within the heterogeneous catalyst (34). Considering these results, the amount of 30 mg of lipases from A. niger and 15 mg of lipases from C. rugosa were selected for the subsequent experiments, which furnished the best results.

Effect of presence of additive

The E-value of the lipases from C. rugosa and A. niger were evaluated when different additives (silica gel, molecular sieves 4ºA and celite) were added and the reactions were examined without addition of water after 24 hours. It should be noted that these solid supports were used as additives, therefore, the lipases were not immobilized onto the supports prior to use.

The results in the Table 4 show that conversion degree of A. niger lipase can be effectively enhance in presence of silica gel, but not significantly in presence of molecular sieves and celite. After 24 h of reaction, the conversion was 36, ee 46% and E-value 15, which is considered moderate to good for synthetic approaches (17).

We observed that the silica gel was uniformly dispersed in the reaction medium and seemed to contribute to the homogeneity of the native lipase, as this lipase forms aggregates in the reaction medium and therefore the mass transfer limitations could be impaired. Probably, the high selectivity obtained was due to an improved dispersion of the catalyst in the organic media in the presence of silica gel. The presence of silica (E = 20) and molecular sieves (E = 23) in the reaction medium was found to have positive effect in the E-value C. rugosa lipase. When celite was used, low selectivity of this lipase (E= 12) was obtained under the present experimental conditions. Additives already present in the commercial powder, such as polysaccharides, dextrans or other products, showed an important influence on the catalytic performance of the Candida rugosa lipase (26,37).

CONCLUSION

This study contributes to the use of native microbial sources for the expansion of biocatalysis in the resolution of racemic drugs. Considerable variability in the enantioselectivity in the resolution of (R,S)-ibuprofen between commercial and native lipases tested was observed. The different hydration degrees of the tested enzymatic preparations and other components present in the commercial powder or produced jointly with the enzyme in the fermentation process are some of the factors that influence the catalytic performance of lipases. When the Aspergillus niger lipase was used as a crude lyophilized powder without additives, the reaction rate was very low (especially in the initial phase) and the conversion degree was only about half of the theoretically expected value (50%). Nevertheless, we show that the enantioselective esterification rate of (R,S)-ibuprofen by Aspergillur niger lipase was markedly enhanced when the concentration of the enzyme was varied, and silica gel (0.5% w/v) was added to the reaction medium. These promising results point out to future applications of these enzymes in the resolution of the (R,S)-ibuprofen after semi-purification, as well as immobilization in different supports.

ACKNOWLEDGEMENTS

Our work has been supported by Fundação de Amparo à Pesquisa do Estado de São Paulo of Brasil (FAPESP 02/06807-9). The authors thank the Centro de Micologia da Universidade de Lisboa (Portugal) and Novozymes Latin America Ltda (Brasil).

Submitted: September 12, 2005; Returned to authors for corrections: March 09, 2006; Approved: May 19, 2006

  • 1. Affeck, R.; Xu, Z.; Suzawa, V.; Focht, K.; Clark, D.S.; Dordick, J.S. Enzymatic catalysis and dynamics in low-water environments. Proc. Natl. Acad. Sci., 89, 1100-1104, 1992.
  • 2. Arroyo, M.; Montero, J.M.S.; Sinisterra, J.V. Thermal stabilization of immobilized lipase B from Candida antarctica on different support: Effect of water activity on enzymatic activity in organic media. Enzyme Microb. Technol, 24, 3-12, 1999.
  • 3. Arroyo, M.; Sinisterra, J.V. High enantioselective esterification of 2-arylpropionic acids catalysed by immobilized lipase of Candida antarctica: a mechanistic approach. J. Org. Chem., 59, 4410-4417, 1994.
  • 4. Berglund, P.; Holmquist, M.; Hult, K. Reversed enantiopreference of Candidarugosa lipase supports different modes of binding enantiomers of chiral acyl donor. J. Mol. Catal.B., 5, 283-287, 1998.
  • 5. Bhandarkar, S.V.; Neau, S.H. Lipase-catalyzed enantioselective esterification of flurbiprofen with n-butanol, EJB Eletronic J. Biotechnol., 33, 01-07, 2000.
  • 6. Cardenas, F.; de Castro-Alvarez, M.S.; Sanchez-Montero, J.M.; Sinisterra, J.V.; Valmaseda, M.; Elson, S.W.; Alvarez, E. Novel microbial lipases: catalytic activity in reactions in organic media. Enzyme Microb. Technol, 28, 145-154, 2001.
  • 7. Cardenas, F.; Alvarez, E.; de Castro-Alvarez, M.S.; Sanchez-Montero, J.M.; Valmaseda, M.; Elson, S.W.; Sinisterra, J.V. Screening and catalytic activity in organic synthesis of novel fungal and yeast lipases. J. Mol. Catal. B: Enzym., 14, 111-123, 2001.
  • 8. Carvalho, P.O.; Calafatti, S.A.; Marassi, M.; Silva, D.M.; Contesini, F.J.; Bizaco, R. Potencial de biocatálise enantioseletiva de lipases microbianas. Quim. Nova, 28, 614-621, 2005.
  • 9. Carvalho, P.O.; Contesini, F.J.; Almeida, A.P.; Macedo, G.A. Kinetic properties and enantioselectivity of the lipases produced by four Aspergillus wilds species. Food Biotechnol., 19, 183-192, 2005.
  • 10. Chamorro, S.; Alcántara, A.R.; de la Casa, R.M.; Sinisterra, J.V.; Sánchez-Montero, J.M. Small water amounts increase the catalytic behaviour of polar organic solvents pre-treated Candida rugosa lipase. J. Mol. Catal. B: Enzym., 11, 939-947, 2001.
  • 11. Chen, C.S.; Sih, C.J. General aspects and optimization of enantioselective biocatalysis in organic solvents. The use of lipases. Angew. Chem., 28, 695, 1989.
  • 12. Chen, C.S.; Fujimoto, Y.; Girdaukas, G.; Sih, C.J. Quantitative analyses of biochemical kinetic resolutions of enantiomers. J. Am. Oil Chem. Soc., 104, 7294-7299, 1982.
  • 13. D' Antona, N.; Lombardi, P.; Nicolosi, G.; Salvo, G. Large scale preparation of enantiopure S-ketoprofen by catalyzed kinetic resolution. Process Biochem, 38, 373-377, 2002.
  • 14. Domínguez de M.P.; Sinisterra, J.V. Causes of unreproducibility of Candidarugosa lipase-catalyzed reactions in slightly hydrate organic media. Tetrahedron, 55, 8555-8566, 1999.
  • 15. Dordick, J.S. Designing enzymes for use in organic solvents. Biotechnol. Prog., 8, 259-67, 1992.
  • 16. Ducret, A.; Trani, M.; Lorti, R. Lipase-catalysed enantioselective esterification of ibuprofen in organic solvents under controlled water activity. Enzyme Microb. Technol., 22, 212-216, 1998.
  • 17. Faber, K. In Biotransformation in Organic Chemistry; 4.ed.; Springer-Verlag: Berlin, 1997; Vol. 1, Chapter 1, pp1-26.
  • 18. Goderis, H.L.; Ampe, G.; Feyten, M.P.; Fouwe, B.L.; Guffens, W.M.; Van-Cauwenbergh, S.M.; Tobback, P.P. Lipase-catalyzed ester exchange reactions in organic media with controlled humidity. Biotechnol. Bioeng, 30, 258-266, 1987.
  • 19. Henke, E.; Schuster, S.; Yang, H.; Bornscheuer, U.E. Lipase-catalyzed resolution of ibuprofen. Monatsh. Chem, 131, 633-638, 2000.
  • 20. Hernáiz, M.J.; Sanchez-Montero, J.M.; Sinisterra, J.V. Comparison of the enzymatic activity of commercial and semipurified lipase of Candida cylindracea in the hydrolysis of the esters of (R,S) 2-aryl propionic acids. Tetrahedron, 50, 10749-10760, 1994.
  • 21. Hernáiz, J.; Sanchez, M.J.M.; Sinisterra, J.V. Hydrolysis of (R,S) 2-aryl propionic esters by pure lipase B from Candida cylindracea J. Mol. Catal. A: Chem, 96, 317-327, 1995.
  • 22. Hernáiz, M.J.; Sánchez-Montero, J.M.; Sinisterra, J.V. Modification of purified lipases from Candida rugosa with polyethylene glycol: A systematic study. Enzyme Microb. Technol., 24, 181-190, 1999.
  • 23. Hernáiz, M.J.; Sánchez-Montero, J.M.; Sinisterra, J.V. New differences between isoenzymes A and B from Candida rugosa lipase. Biotechnol. Lett., 19, 303-306, 1997.
  • 24. Hernáiz, M.J.; Sanchez-Montero, J.M.; Sinisterra, J.V. Comparison of the enzymatic activity of commercial and semipurified lipase of Candida cylindracea in the hydrolysis of the esters of (R,S) 2-aryl propionic acids. Tetrahedron, 50, 10749-10760, 1994.
  • 25. Hernáiz, J.; Sanchez, M.J.M.; Sinisterra, J.V. Hydrolysis of (R,S) 2-aryl propionic esters by pure lipase B from Candida cylindracea J. Mol. Catal. A: Chem, 96, 317-327, 1995.
  • 26. Högberg, H-E.; Edlund, H.; Berglund, P.; Hedenström, E. Water activity influences enantioselectivity in a lipase-catalysed resolution by esterification in an organic solvent Tetrahedron: Asymmetry, 4, 2123-2126, 1993.
  • 27. Hutt, A.J.; Caldwell, J. The importance of stereochemistry in the clinical pharmacokinetics of the 2-arylpropionic acid nonsteroidal anti-inflammatory drugs. Clin. Pharmacokin., 9, 371-373, 1984.
  • 28. Kim, M.G.; Lee, S.B. Enzymatic resolution of racemic ibuprofen by lipase-catalyzed esterification reaction: Effects of water content and solid supports. J. Ferment. Bioeng., 81, 269-271, 1996.
  • 29. Kumar, I.; Manju, K.; Jolly, R.S. A new biocatalyst for the preparation of enantiomeically pure 2-arylpropionic acids. Tetrahedron: Assymetry, 12, 1431-1434, 2001.
  • 30. Lee, W.H.; Kim, K.-J.; Kim, M.G.; Lee, S.B. Enzymatic resolution of racemic ibuprofen esters: effects of organic cosolvents and temperature. J Ferment Bioeng, 80, 613-615, 1995.
  • 31. López-Belmonte, T.; Alcántara, A.R.; Sinisterra, J.V. Enantioselective esterification of 2-aryl propionic acids catalyzed by immobilized Rhizomucor miehei lipase. J. Org. Chem., 62, 1831-1840, 1997.
  • 32. López, N.; Pernas, M.A.; Pastrana, L.M.; Sánchez, A.; Valero, F.; Rua, M.L. Reactivity of pure Candida rugosa lipase isoenzymes (Lip1, Lip2 and Lip3) in aqueous and organic media. Influence of the isoenzymatic profile on the lipase performance in organic media. Biotechnol. Prog., 20, 65-73, 2004.
  • 33. Lowry, O.H.; Rosenbrough, N.J.; Farr, A.L.; Randall, R.J. Protein Measurement with the Folin Phenol Reagent. J. Biol. Chem., 193, 265-275, 1951.
  • 34. Mustranta, A. Use of lipases in the resolution of racemic ibuprofen. Appl. Microbiol. Biotechnol., 38, 61-66, 1992.
  • 35. Nakayama, K. Sources of industrial microorganisms. In: Rehm, H.-J.; Reed, G. (eds). Biotechnology, Microbial Fundamentals, Verlag Chemie, Veinheim, 1981, p.355-410.
  • 36. Park, D.-W.; Haam, S.; Ahn, I.-S.; Lee, T.G.; Kim, H.-S.; Kim, W.-S. Enzymatic esterification of b-methylglucoside with acrylic/methacrylic acid in organic solvents. J. Biotechnol., 107, 151-160, 2004.
  • 37. Sakaki, K.; Giorno, L.; Drioli, E. Lipase-catalyzed optical resolution of racemic naproxen in biphasic enzyme membrane reactors. J. Membr. Sci., 184, 27-38, 2001.
  • 38. Sánchez, A.; Ferrer, P.; Serrano, A.; Valero, F.; Solà, C.; Pernas, M.; Rúa, M.L.; Fernández-Lafuente, R.; Guisán, J.M.; Casa, R.M.; Sinisterra, J.V.; Sánchez-Montero, J.M. A controlled fed-batch cultivation for the production of new crude lipases from Candida rugosa with improved properties in fine chemistry. J. Biotechnol., 69, 169-182, 1999.
  • 39. Sánchez, A.; De La Casa, R.M.; Sinisterra, J.V.; Valero, F.; Sánchez-Monteros, J.M. Effect of fermentation conditions in the enzymatic activity and stereoselective of crude lipase from Candida rugosa Appl. Biochem. Biotechnol., 80, 65-75, 1999.
  • 40. Santaniello, E.; Ferraboschi, P.; Grisenti, P. Lipaze-catalyzed transesterification in organic solvents: Applications to the preparation of enantiomerically pure compounds. Enzyme Microb. Technol., 15, 367-382, 1993.
  • 41. Shang, C.-S.; Hsu, C.-S. Lipase-catalyzed enantioselective esterification of (S)-naproxen hydroxyalkil ester in organic media. Biotechnol. Lett, 25, 413-416, 2003.
  • 42. Sih, C.J.; Gu, Q.; Fulling, G.; Wu, S.; Reddy, D.R. The use of microbial enzymes for the synthesis of optically active pharmaceuticals. Dev. Ind. Microbiol., 29, 221-229, 1988.
  • 43. Steenkamp, L.; Brady, D. Screening of commercial enzymes for the enantioselective hydrolysis of R,S-naproxen ester. Enzyme Microb. Technol., 32, 472-477, 2003.
  • 44. Stuer, W.; Jaeger, K.E.; Winkler, U.K. Purification of extracellular lipase from Pseudomonas aeruginosa.J. Bacteriol., 168, 1070-1074, 1986.
  • 45. Tsai, S.W.; Wei, H.J. Enantioselective esterification of racemic naproxen by lipases in organic solvent. Enzyme Microb. Technol., 16, 328-332, 1994.
  • 46. Xie, Y.-C.; Liu, H.-Z.; Chen, J.-Y. Candidarugosa lipase catalyzed esterification of racemic ibuprofen with butanol: racemization of R-ibuprofen and chemical hydrolysis of S-ester formed. Biotechnol. Lett., 20, 455-458, 1998.
  • 47. Xie, Y.-C.; Liu, H.-Z.; Chen, J.-Y. Effect of water content on enzyme activity and enantioselectivity of lipase-catalyzed esterification of racemic ibuprofen in organic solvents. Annals New York Academy of Sciences, 570-575, 1998.
  • 48. Xin, J.-Y.; Li, S.-B.; Chen, X.-H.; Wang, L.-L.; Xu, Y. Improvement of the enantioselectivity of lipase-catalyzed naproxen ester hydrolysis in organic solvent. Enzyme Microb. Technol., 26, 137-141, 2000.
  • 49. Zaks, A.; Klibanov, A.M. The effect of water on enzyme action in organic media. J. Biol. Chem, 263, 8017-8021, 1988.
  • *
    Corresponding author. Mailing address: Rua Santo Monte, 65, Jardim Salessi.13251-131, Itatiba, SP, Brasil.Tel.: (+5511) 4034-8298, Fax: (+5511) 4034-1825 E-mail:
  • Publication Dates

    • Publication in this collection
      18 Dec 2006
    • Date of issue
      Sept 2006

    History

    • Accepted
      19 May 2006
    • Reviewed
      09 Mar 2006
    • Received
      12 Sept 2005
    Sociedade Brasileira de Microbiologia USP - ICB III - Dep. de Microbiologia, Sociedade Brasileira de Microbiologia, Av. Prof. Lineu Prestes, 2415, Cidade Universitária, 05508-900 São Paulo, SP - Brasil, Ramal USP 7979, Tel. / Fax: (55 11) 3813-9647 ou 3037-7095 - São Paulo - SP - Brazil
    E-mail: bjm@sbmicrobiologia.org.br